Product ID:ADHESIVE COATING - RED, FOSTER 30-7, #31158
MSDS Date:12/30/1994
FSC:8040
NIIN:01-097-4518
MSDS Number: CBTSZ

FOSTER PRODUCTS, CORP.

3900 JACKSON ST. NE
MINNEAPOLIS, MN 55421
US

Emergency Phone: 800-228-5635 EX 018/800-424-9300

Info Phone: 612-781-8071/FAX 612-782-1755

Cage: KO427

FOSTER PRODUCTS, CORP.

MINNEAPOLIS, MN 55421 US

Telephone: 612-781-8071/FAX 612-782-1755

Cage: KO427

CHLORINATED PARAFFIN (SARA 313)(VP NIL @ 20C)

CAS: 63449-39-8

RTECS: RV0480000

Fraction By Weight: 10-30%

55F)(LD50 7060

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 1-5%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

RESIDUAL VINYL ACETATE MONOMER (SARA III)(LEL 2.6%)(VP=92 @

CAS: 108-05-4

RTECS: AK0875000

Fraction By Weight: <2.0%

OSHA PEL 10 PPM/STEL 20

ACGIH TLV: 10 PPM/STEL 20

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

VOC = 49 G/L OF MATERIAL LESS WATER & EXEMPT SOLVENTS

RTECS: 9999999VO

OSHA PEL NOT RELEVANT

ACGIH TLV: NOT RELEVANT

CALCIUM CARBONATE (MARBLE) (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 10-15%

OSHA PEL 15MG/M3TDUST/RESP 5

ACGIH TLV: 10 MG/M3 TDUST

KAOLIN

CAS: 1332-58-7

RTECS: GF1670500

Fraction By Weight: 10-30%

OSHA PEL 15MG/M3TDUST/RESP 5

ACGIH TLV: 10MG/M3TDUST/RESP 2

SILICA, CRYSTALLINE

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.1-1.0%

OSHA PEL 0.1 MG/M3 RESP DUST

ACGIH TLV: 0.1 MG/M3 RESP DUST

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT W/PROD/HIGH VAPOR LEVEL
CAUSES IRRIT.LIQ CONTACT DRIES/DEFATS SKIN.CHRONIC CONTACT MAY
CAUSE IRRIT/SENSITIZATION.INHAL: OVEREXPOSURE TO VAPORS CAUSE IRRIT
TO NOSE/THROAT/RESP TRACT.MAY C AUSE
DIZZINESS/HEADACHE/NAUSEA/UNCONSCIOUSNESS.INGEST: HARMFUL. CHRONIC:
CRYSTALINE SILICA OVEREXPOS MAY CAUSE PERM*
Explanation of Carcinogenicity:CHLORINATED PARAFFIN IDENTIFIED AS
ANIMAL CARCINOGEN IN ANIMALS. VINYL ACETATE SHOWN TO CAUSE CANCER
IN ANIMALS.**
Effects of Overexposure:NK *LUNG DAMAGE/REDUCED PULMINARY FUNCTION.
SOLVENTS MAY CAUSE LIVER/KIDNEY DAMAGE. **CRYSTALINE SILICA LISTED
AS POTENTIAL CARCINOGEN BY NTP/IARC.
Medical Cond Aggravated by Exposure:NO KNOWN EFFECTS ON OTHER
ILLNESSES.

First Aid:EYE: FLUSH IMMEDIATELY W/LARGE AMOUNTS WATER 15 MINUTES. CALL
DR. SKIN: WASH AFFECTED AREA W/SOAP & WATER. INHALATION: REMOVE
FROM EXPOSURE. RESTORE BREATHING IF NECESSARY. KEEP WARM/QUIET.
CALL DR. I NGESTION: IF PERSON CAN SWALLOW GIVE 1 GLASS WATER/MILK.
DON'T INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Autoignition Temp:Autoignition Temp Text:NE
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO2.
Fire Fighting Procedures:PERSONS EXPOSED TO PRODUCTS OF COMBUSTION
SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
BUILDUP IN CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED
TO COOL THE CONTAINERS.

Spill Release Procedures:REMOVE ALL IGNIT SOURCES. VENTILATE AREA.
AVOID BREATHING VAPORS. DIKE/CONTAIN SPILL W/INERT ABSORBENT,
TRANSFER TO CONTAINER FOR DISPOSAL. USE NONSPARKING TOOLS. KEEP
SPILL OUT OF SEWERS.

Handling and Storage Precautions:GROUND DRUMS WHEN POURING. KEEP AWAY
FROM HEAT/SPARKS/FLAME. KEEP CONTAINER CLOSED.AVOID BREATHING
VAPORS. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHES. WASH THOROUGHLY
AFTER HANDLING. EMPTIED CONTAINER RETAINS VAPOR/PRODUCT RESIDUE.
OBSERVE ALL LABEL PRECAUTIONS UNTIL CONTAINER IS CLEANED. DON'T CUT
OR WELD ON/NEA R CONTAINER.

Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT. ORGANIC VAPOR
RESPIRATORS WHEN AIRBORNE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST PREFERRED. PROVIDE VENT TO CONTROL
CONTAMINANT LEVELS BELOW AIRBORNE EXPOSURE LIMITS.
Protective Gloves:RUBBER GLOVES
Eye Protection:WEAR SAFETY GLASSES, CHEM SAFETY GOGGLES
Other Protective Equipment:HAVE EYE WASHES AVAILABLE WHERE EYE CONTACT
CAN OCCUR. PREVENT PROLONGED/REPEATED CONTACT W/PROTECTIVE
CLOTHING.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:NOT EST.
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NOT EST.
Vapor Density:NOT EST.
Spec Gravity:1.27
pH:7.8
Evaporation Rate & Reference:NOT EST.
Appearance and Odor:RED LIQUID, PUNGENT SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:HYDROGEN CHLORIDE & PHOSGENE.
INCOMPLETE COMBUSTION CAN YIELD LOW MOLLECULAR WEIGHT HYDROCARBONS,
CARBON MONOXIDE.

Waste Disposal Methods:HAZARDOUS WASTE PER 40 CFR 261, IGNITABLE WASTE
CLASS D001. DISPOSAL BY INCINERATION RECOMMENDED. CONSULT LOCAL,
STATE,FEDERAL AUTHORITIES FOR MORE RESTRICTIVE REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.